2003-2009 GMC C5500 Kodiak labor times
8.1L Vortec V8
These times cover the GMC C5500 Kodiak 8.1L Vortec V8 for model years 2003, 2004, 2005, 2006, 2007, 2008, 2009.
Change vehicle
per hour
Enter a rate to see the labor cost of each job. Many US shops charge somewhere between $100 and $200 an hour.
Most looked up
- Brake Pads - Front1.4 hr1.1 to 1.7
- Brake Rotors - Front Pair1.6 hr1.3 to 1.9
- Oil Change0.5 hr0.4 to 0.6
- Alternator1.4 hr1.2 to 1.6
- Starter1.8 hr1.4 to 2.2
- Water Pump3.0 hr2.4 to 3.6
- Thermostat1.6 hr1.4 to 1.8
- Timing Chain8.4 hr6.7 to 10.1
Maintenance
- 100K Service4.2 hr3.4 to 5.0
- 30K Service2.4 hr2.0 to 2.8
- 60K Service3.4 hr2.9 to 3.9
- 90K Service2.7 hr2.3 to 3.1
- AC System Diagnosis1.2 hr1.0 to 1.4
- Air Filter0.4 hr0.3 to 0.5
- Battery Test0.4 hr0.3 to 0.5
- Charging System Test0.5 hr0.4 to 0.6
- Check Engine Light Diagnosis1.2 hr1.0 to 1.4
- Compression Test2.6 hr2.2 to 3.0
- Cooling System Pressure Test0.6 hr0.5 to 0.7
- Diagnostic Scan0.6 hr0.5 to 0.7
- Differential Service1.2 hr1.0 to 1.4
- Drivability Diagnosis1.2 hr1.0 to 1.4
- Electrical Diagnosis1.2 hr1.0 to 1.4
- Emissions Inspection0.6 hr0.5 to 0.7
- Fluid Leak Diagnosis0.9 hr0.8 to 1.0
- Leak-Down Test1.8 hr1.4 to 2.2
- Noise Diagnosis1.0 hr0.8 to 1.2
- Oil Change - Synthetic0.4 hr0.3 to 0.5
- Power Steering Service1.1 hr0.9 to 1.3
- Pre-Purchase Inspection1.8 hr1.4 to 2.2
- State Inspection0.6 hr0.5 to 0.7
- Tire Balance1.3 hr1.1 to 1.5
- Tire Mount and Balance1.9 hr1.6 to 2.2
- Tire Rotation1.1 hr0.9 to 1.3
- TPMS Relearn0.4 hr0.3 to 0.5
- TPMS Sensor0.6 hr0.5 to 0.7
- Transmission Service1.8 hr1.4 to 2.2
- Tune-Up - Major3.0 hr2.4 to 3.6
- Tune-Up - Minor1.4 hr1.2 to 1.6
- Wheel Alignment1.2 hr1.0 to 1.4
- Wiper Blade Replacement0.3 hr0.2 to 0.4
Brakes
- ABS Module1.4 hr1.2 to 1.6
- ABS Pump2.3 hr2.0 to 2.6
- ABS Tone Ring - Front1.6 hr1.4 to 2.0
- ABS Tone Ring - Rear2.0 hr1.7 to 2.5
- ABS Wheel Speed Sensor - Front0.6 hr0.5 to 0.7
- ABS Wheel Speed Sensor - Rear1.2 hr1.0 to 1.4
- Brake Bleed - All Four0.9 hr0.7 to 1.1
- Brake Booster1.8 hr1.4 to 2.2
- Brake Booster Check Valve0.6 hr0.5 to 0.7
- Brake Caliper - Front1.2 hr1.0 to 1.4
- Brake Caliper - Rear1.3 hr1.1 to 1.5
- Brake Caliper Bracket - Front0.8 hr0.7 to 1.0
- Brake Caliper Bracket - Rear0.8 hr0.7 to 1.0
- Brake Caliper Rebuild - Front1.9 hr1.6 to 2.2
- Brake Caliper Rebuild - Rear2.0 hr1.7 to 2.3
- Brake Drum - Rear1.8 hr1.4 to 2.2
- Brake Fluid Flush1.0 hr0.8 to 1.2
- Brake Hose - Front1.0 hr0.8 to 1.2
- Brake Hose - Rear1.0 hr0.8 to 1.2
- Brake Light Switch0.5 hr0.4 to 0.6
- Brake Line - Single0.9 hr0.7 to 1.1
- Brake Lines - Complete Set6.6 hr5.3 to 7.9
- Brake Master Cylinder1.8 hr1.4 to 2.2
- Brake Master Cylinder Rebuild2.5 hr2.1 to 2.9
- Brake Pads - Front1.4 hr1.1 to 1.7
- Brake Pads - Rear1.4 hr1.1 to 1.7
- Brake Pads and Rotors - Front2.2 hr1.8 to 2.6
- Brake Pads and Rotors - Rear2.2 hr1.8 to 2.6
- Brake Proportioning Valve1.2 hr1.0 to 1.4
- Brake Rotor - Front Single0.5 hr0.4 to 0.6
- Brake Rotor - Rear Single0.6 hr0.5 to 0.7
- Brake Rotors - Front Pair1.6 hr1.3 to 1.9
- Brake Rotors - Rear Pair2.3 hr1.8 to 2.8
- Caliper Slide Pins - Front0.7 hr0.6 to 0.9
- Caliper Slide Pins - Rear0.7 hr0.6 to 0.9
- Drum Brake Hardware Kit2.4 hr1.9 to 2.9
- Drum Brake Shoes - Rear1.8 hr1.4 to 2.2
- Electronic Parking Brake Motor1.1 hr0.9 to 1.3
- Front Brake Pad Replacement1.5 hr1.3 to 1.7
- Parking Brake Actuator1.2 hr1.0 to 1.4
- Parking Brake Cable1.5 hr1.3 to 1.7
- Parking Brake Shoes1.8 hr1.4 to 2.2
- Rear Brake Shoe Replacement2.2 hr1.9 to 2.5
- Wheel Cylinder1.2 hr1.0 to 1.4
Engine
- Boost Pressure Sensor0.6 hr0.5 to 0.7
- Camshaft Position Sensor1.8 hr1.5 to 2.1
- Camshaft R&R11.7 hr9.4 to 14.0
- Connecting Rod Bearings13.0 hr11.1 to 15.0
- Crankshaft Position Sensor1.2 hr1.0 to 1.4
- Crankshaft R&R21.0 hr17.9 to 24.2
- Cylinder Head R&R10.3 hr8.8 to 11.8
- Cylinder Head Resurface10.2 hr8.2 to 12.2
- Engine Mount - Front3.0 hr2.6 to 3.5
- Engine Mount - Rear3.3 hr2.8 to 3.8
- Engine Mounts - All5.5 hr4.4 to 6.6
- Engine R&R15.5 hr13.2 to 17.8
- Engine Rebuild36.0 hr30.6 to 41.4
- Exhaust Manifold3.0 hr2.6 to 3.5
- Exhaust Manifold Gasket3.6 hr2.9 to 4.3
- Fan Belt Replacement1.1 hr0.9 to 1.3
- Flexplate8.0 hr6.8 to 9.2
- Flywheel9.0 hr7.2 to 10.8
- Freeze Plug - Single4.2 hr3.4 to 5.0
- Freeze Plugs - All10.0 hr8.5 to 11.5
- Front Main Seal4.0 hr3.4 to 4.6
- Full Engine Tune-Up3.0 hr2.4 to 3.6
- Harmonic Balancer2.4 hr1.9 to 2.9
- Head Gasket - Single10.8 hr9.2 to 12.4
- Head Gaskets - Both16.4 hr13.1 to 19.7
- Idle Air Control Valve0.7 hr0.6 to 0.8
- Idler Pulley1.0 hr0.8 to 1.2
- Intake Manifold4.2 hr3.4 to 5.0
- Intake Manifold Gasket3.6 hr2.9 to 4.3
- Intercooler2.5 hr2.1 to 2.9
- Knock Sensor1.8 hr1.4 to 2.2
- Lifter - Single10.3 hr8.8 to 11.8
- Lifters/Tappets - All13.3 hr10.6 to 16.0
- Long Block Replacement16.8 hr13.4 to 20.2
- Main Bearings19.2 hr15.4 to 23.0
- Manifold Absolute Pressure Sensor0.6 hr0.5 to 0.7
- Mass Air Flow Sensor0.6 hr0.5 to 0.7
- Oil Change0.5 hr0.4 to 0.6
- Oil Level Sensor1.0 hr0.9 to 1.2
- Oil Pan Gasket4.2 hr3.4 to 5.0
- Oil Pan Replacement4.2 hr3.4 to 5.0
- Oil Pressure Sensor1.0 hr0.8 to 1.2
- Oil Pump7.8 hr6.2 to 9.4
- Oil Separator/PCV1.2 hr1.0 to 1.4
- PCV Valve0.5 hr0.4 to 0.6
- Piston - Single14.0 hr11.9 to 16.1
- Piston Rings - All21.6 hr17.3 to 25.9
- Pistons - All24.0 hr20.4 to 27.6
- Rear Main Seal9.0 hr7.2 to 10.8
- Rocker Arms - All4.6 hr3.9 to 5.3
- Serpentine Belt0.7 hr0.6 to 0.8
- Serpentine Belt Tensioner1.2 hr1.0 to 1.4
- Short Block Replacement21.6 hr17.3 to 25.9
- Throttle Body1.2 hr1.0 to 1.4
- Throttle Position Sensor1.0 hr0.8 to 1.2
- Timing Chain8.4 hr6.7 to 10.1
- Timing Chain Guide7.8 hr6.2 to 9.4
- Timing Chain Kit11.8 hr10.0 to 13.6
- Timing Chain Tensioner9.9 hr8.4 to 11.4
- Transmission Mount1.8 hr1.4 to 2.2
- Valve Adjustment3.0 hr2.4 to 3.6
- Valve Cover Gasket - Single1.8 hr1.4 to 2.2
- Valve Cover Gaskets - Both3.9 hr3.1 to 4.7
- Valve Job - Complete16.0 hr13.6 to 18.4
- Valve Seals10.2 hr8.2 to 12.2
- Valve Spring - Single5.5 hr4.7 to 6.3
- Valve Springs - All10.2 hr8.2 to 12.2
- Variable Valve Timing Actuator8.0 hr6.8 to 9.2
- VVT Solenoid - Single1.2 hr1.0 to 1.4
- VVT Solenoids - All2.3 hr1.8 to 2.8
Cooling
- Coolant Bypass Pipe2.5 hr2.0 to 3.0
- Coolant Flush1.0 hr0.8 to 1.2
- Coolant Outlet1.6 hr1.4 to 1.8
- Coolant Reservoir0.6 hr0.5 to 0.7
- Coolant Temperature Sensor0.5 hr0.4 to 0.6
- Cooling Fan Assembly1.4 hr1.1 to 1.7
- Cooling Fan Clutch1.7 hr1.4 to 2.0
- Cooling Fan Motor1.4 hr1.1 to 1.7
- Cooling Fan Relay0.6 hr0.5 to 0.7
- Engine Oil Cooler3.0 hr2.4 to 3.6
- Heater Control Valve1.1 hr0.9 to 1.3
- Heater Core5.2 hr4.4 to 6.0
- Heater Hoses1.4 hr1.2 to 1.6
- Radiator3.6 hr3.1 to 4.1
- Radiator Cap0.2 hr
- Radiator Hose - Lower0.6 hr0.5 to 0.7
- Radiator Hose - Upper0.6 hr0.5 to 0.7
- Radiator Hoses - Both1.6 hr1.4 to 1.8
- Radiator Removal and Service4.3 hr3.7 to 4.9
- Thermostat1.6 hr1.4 to 1.8
- Thermostat Housing1.9 hr1.6 to 2.2
- Water Pump3.0 hr2.4 to 3.6
Ignition
- Coil Pack1.0 hr0.8 to 1.2
- Distributor1.3 hr1.1 to 1.5
- Distributor Cap and Rotor0.6 hr0.5 to 0.7
- Distributor Rebuild2.0 hr1.7 to 2.3
- Ignition Coil - Single0.4 hr0.3 to 0.5
- Ignition Coils - All2.3 hr1.8 to 2.8
- Ignition Control Module0.8 hr0.7 to 0.9
- Ignition Lock Cylinder0.9 hr0.8 to 1.0
- Ignition Switch1.1 hr0.9 to 1.3
- Ignition System Theory of Operation0.4 hr0.3 to 0.5
- Ignition Timing Adjustment0.6 hr0.5 to 0.7
- Spark Plug Wires1.6 hr1.4 to 1.8
- Spark Plugs2.3 hr2.0 to 2.6
- Spark Plugs - V61.8 hr1.4 to 2.2
- Spark Plugs - V81.8 hr1.4 to 2.2
Fuel system
- Charcoal Canister1.0 hr0.8 to 1.2
- EVAP Purge Valve0.6 hr0.5 to 0.7
- EVAP Vent Valve1.0 hr0.8 to 1.2
- Fuel Cap0.1 hr
- Fuel Filler Neck1.4 hr1.1 to 1.7
- Fuel Filter0.6 hr0.5 to 0.7
- Fuel Filter - In-Tank2.6 hr2.2 to 3.0
- Fuel Injection System Diagnostics and Troubleshooting1.8 hr1.4 to 2.2
- Fuel Injection System Theory of Operation0.5 hr0.4 to 0.6
- Fuel Injector - Single0.9 hr0.7 to 1.1
- Fuel Injector Cleaning1.2 hr1.0 to 1.4
- Fuel Injectors - All10.3 hr8.8 to 11.8
- Fuel Level Sensor1.8 hr1.4 to 2.2
- Fuel Line - High Pressure1.8 hr1.4 to 2.2
- Fuel Line - Return1.8 hr1.4 to 2.2
- Fuel Line and Filter Service1.3 hr1.1 to 1.5
- Fuel Pressure Regulator1.4 hr1.1 to 1.7
- Fuel Pump2.4 hr1.9 to 2.9
- Fuel Pump Module2.9 hr2.5 to 3.3
- Fuel Rail3.0 hr2.4 to 3.6
- Fuel Tank2.6 hr2.2 to 3.0
- Fuel Tank Strap1.4 hr1.2 to 1.6
- High Pressure Fuel Pump5.3 hr4.5 to 6.1
Electrical
- Airbag - Driver0.7 hr0.6 to 0.8
- Airbag - Passenger1.4 hr1.2 to 1.6
- Airbag - Side1.2 hr1.0 to 1.4
- Airbag Module/Computer1.1 hr0.9 to 1.3
- Alternator1.4 hr1.2 to 1.6
- Alternator Belt0.6 hr0.5 to 0.7
- Amplifier0.8 hr0.7 to 0.9
- Antenna0.6 hr0.5 to 0.7
- Backup Camera1.1 hr0.9 to 1.3
- Battery0.5 hr0.4 to 0.6
- Battery Cable - Negative0.5 hr0.4 to 0.6
- Battery Cable - Positive1.0 hr0.8 to 1.2
- Battery Cables - Both1.6 hr1.3 to 1.9
- Battery Terminal0.4 hr0.3 to 0.5
- Blower Motor1.2 hr1.0 to 1.4
- Blower Motor Control Module0.8 hr0.7 to 0.9
- Blower Motor Resistor0.6 hr0.5 to 0.7
- Clock Spring1.0 hr0.9 to 1.2
- Combination Switch1.2 hr1.0 to 1.4
- Dimmer Switch0.7 hr0.6 to 0.8
- Door Lock Actuator - Front1.1 hr0.9 to 1.3
- Door Lock Actuator - Rear1.2 hr1.0 to 1.4
- Fog Light Assembly0.6 hr0.5 to 0.7
- Fog Light Bulb0.4 hr0.3 to 0.5
- Fuel Pump Relay0.6 hr0.5 to 0.7
- Fuse Box - Engine Bay1.2 hr1.0 to 1.4
- Fuse Box - Interior1.4 hr1.2 to 1.6
- Generator Service and Rebuild2.5 hr2.1 to 2.9
- Headlight Assembly0.6 hr0.5 to 0.7
- Headlight Assembly - Pair0.9 hr0.8 to 1.0
- Headlight Bulb - Single0.4 hr0.3 to 0.5
- Headlight Bulbs - Pair0.5 hr0.4 to 0.6
- Headlight Switch0.6 hr0.5 to 0.7
- Heated Seat Module0.9 hr0.8 to 1.0
- HID Ballast0.8 hr0.7 to 0.9
- Horn0.5 hr0.4 to 0.6
- Horn Relay0.6 hr0.5 to 0.7
- Instrument Cluster0.9 hr0.8 to 1.0
- Instrument Cluster Service1.6 hr1.4 to 1.8
- LED Headlight Module0.8 hr0.7 to 0.9
- Main Relay0.4 hr0.3 to 0.5
- Power Antenna Motor1.0 hr0.8 to 1.2
- Power Inverter - Aftermarket Install2.0 hr1.7 to 2.3
- Power Inverter (120V Outlet)1.0 hr0.9 to 1.2
- Power Mirror Motor0.9 hr0.8 to 1.0
- Power Seat Motor1.5 hr1.3 to 1.7
- Power Window Motor - Front1.3 hr1.1 to 1.5
- Power Window Motor - Rear1.4 hr1.2 to 1.6
- Power Window Regulator - Front1.4 hr1.2 to 1.6
- Power Window Regulator - Rear1.5 hr1.3 to 1.7
- Radio/Head Unit0.8 hr0.6 to 1.0
- Relay - Generic0.3 hr0.2 to 0.4
- Seat Heater Element2.5 hr2.1 to 2.9
- Side Mirror Assembly0.8 hr0.6 to 1.0
- Speaker - Dash0.8 hr0.6 to 1.0
- Speaker - Door0.7 hr0.6 to 0.8
- Speedometer1.1 hr0.9 to 1.3
- Speedometer Cable1.0 hr0.9 to 1.2
- Starter1.8 hr1.4 to 2.2
- Starter Solenoid1.8 hr1.4 to 2.2
- Subwoofer0.9 hr0.8 to 1.0
- Sunroof Motor1.4 hr1.2 to 1.6
- Sunroof Switch0.6 hr0.5 to 0.7
- Tail Light Assembly0.6 hr0.5 to 0.7
- Tail Light Bulb0.3 hr0.2 to 0.4
- Third Brake Light0.6 hr0.5 to 0.7
- Trunk/Liftgate Actuator0.9 hr0.8 to 1.0
- Turn Signal Bulb - Front0.4 hr0.3 to 0.5
- Turn Signal Bulb - Rear0.4 hr0.3 to 0.5
- Turn Signal Switch1.2 hr1.0 to 1.4
- Voltage Regulator1.5 hr1.3 to 1.7
- Washer Pump0.6 hr0.5 to 0.7
- Washer Reservoir0.8 hr0.6 to 1.0
- Window Motor and Regulator - Front1.5 hr1.3 to 1.7
- Window Motor and Regulator - Rear1.8 hr1.4 to 2.2
- Wiper Linkage1.5 hr1.2 to 1.8
- Wiper Motor - Front1.2 hr1.0 to 1.4
- Wiper Motor - Rear0.9 hr0.8 to 1.0
- Wiper Switch0.8 hr0.6 to 1.0
Suspension
- Air Line1.0 hr0.9 to 1.2
- Air Spring/Air Bag1.8 hr1.4 to 2.2
- Air Suspension Compressor2.0 hr1.7 to 2.3
- Air Suspension Height Sensor0.9 hr0.8 to 1.0
- Air Suspension Valve Block1.5 hr1.3 to 1.7
- Ball Joint - Lower2.6 hr2.2 to 3.0
- Ball Joint - Upper2.3 hr1.8 to 2.8
- Ball Joints - Upper and Lower4.6 hr3.9 to 5.3
- Coil Spring - Front2.4 hr1.9 to 2.9
- Coil Springs - Front Pair3.3 hr2.6 to 4.0
- Control Arm Bushing - Front Lower1.8 hr1.4 to 2.2
- Front Struts - Pair3.9 hr3.1 to 4.7
- Front Suspension Rebuild11.5 hr9.8 to 13.2
- Kingpin & Bushing Replacement - Both Sides8.5 hr7.2 to 9.8
- Knuckle/Spindle - Front2.5 hr2.0 to 3.0
- Lateral Arm1.8 hr1.4 to 2.2
- Leaf Spring3.5 hr3.0 to 4.0
- Leaf Spring Bushing1.8 hr1.4 to 2.2
- Leaf Spring Shackle1.8 hr1.4 to 2.2
- Leaf Spring U-Bolt Kit1.8 hr1.4 to 2.2
- Lower Control Arm2.4 hr1.9 to 2.9
- Lower Control Arm - Front1.8 hr1.4 to 2.2
- Panhard Bar/Track Bar1.5 hr1.3 to 1.7
- Radius Arm2.4 hr2.0 to 2.8
- Radius Arm Bushing2.4 hr1.9 to 2.9
- Rear Shocks - Pair1.5 hr1.3 to 1.7
- Rear Suspension Service2.5 hr2.0 to 3.0
- Shock Absorber - Front (one side)0.6 hr0.5 to 0.8
- Shock Absorber - Rear (one side)0.6 hr0.5 to 0.8
- Strut Assembly - Front1.8 hr1.4 to 2.2
- Strut Bearing2.4 hr1.9 to 2.9
- Strut Mount - Front2.4 hr1.9 to 2.9
- Subframe12.3 hr10.5 to 14.1
- Subframe Bushing4.2 hr3.4 to 5.0
- Sway Bar - Front1.4 hr1.1 to 1.7
- Sway Bar - Rear1.4 hr1.1 to 1.7
- Sway Bar Bushing - Front1.2 hr1.0 to 1.4
- Sway Bar Bushing - Rear1.0 hr0.8 to 1.2
- Sway Bar Link - Front0.6 hr0.5 to 0.7
- Sway Bar Link - Rear0.7 hr0.6 to 0.8
- Sway Bar Links - Front Pair1.1 hr0.9 to 1.3
- Torsion Bar2.4 hr1.9 to 2.9
- Torsion Bar Adjustment0.6 hr0.5 to 0.7
- Trailing Arm2.4 hr2.0 to 2.8
- Trailing Arm Bushing2.5 hr2.0 to 3.0
- Upper Control Arm1.5 hr1.2 to 1.8
Steering
- Center Link/Drag Link1.8 hr1.4 to 2.2
- Electric Power Steering Module0.6 hr0.5 to 0.7
- Electric Power Steering Motor0.9 hr0.8 to 1.0
- Idler Arm1.4 hr1.1 to 1.7
- Pitman Arm1.3 hr1.1 to 1.5
- Power Steering Fluid Flush1.1 hr0.9 to 1.3
- Power Steering Gear Box3.0 hr2.6 to 3.5
- Power Steering Hose - High Pressure1.4 hr1.1 to 1.7
- Power Steering Hose - Return1.1 hr0.9 to 1.3
- Power Steering Pump1.8 hr1.4 to 2.2
- Power Steering Pump Pulley0.9 hr0.8 to 1.0
- Power Steering Rack3.1 hr2.6 to 3.6
- Power Steering Reservoir1.0 hr0.8 to 1.2
- Rack and Pinion Boots1.1 hr0.9 to 1.3
- Steering Angle Sensor0.8 hr0.7 to 0.9
- Steering Box Adjustment0.6 hr0.5 to 0.7
- Steering Column2.6 hr2.2 to 3.0
- Steering Coupler1.0 hr0.9 to 1.2
- Steering Damper0.6 hr0.5 to 0.7
- Steering Shaft - Intermediate1.1 hr0.9 to 1.3
- Steering Shaft - Upper1.8 hr1.4 to 2.2
- Steering Wheel0.6 hr0.5 to 0.7
- Tie Rod Assembly1.5 hr1.2 to 1.8
- Tie Rod End - Inner1.2 hr1.0 to 1.4
- Tie Rod End - Outer0.7 hr0.6 to 0.8
- Tie Rods - Both Sides1.5 hr1.3 to 1.7
Drivetrain
- 4WD Actuator1.6 hr1.4 to 1.8
- Axle Seal - Front3.0 hr2.4 to 3.6
- Axle Seal - Rear1.8 hr1.4 to 2.2
- Axle Shaft - Rear1.7 hr1.4 to 2.0
- CV Axle - Front3.3 hr2.8 to 3.8
- CV Axle - Rear2.4 hr1.9 to 2.9
- CV Axles - Front Pair3.9 hr3.1 to 4.7
- CV Boot - Inner3.0 hr2.4 to 3.6
- CV Boot - Outer2.9 hr2.5 to 3.3
- Differential Cover Gasket1.8 hr1.4 to 2.2
- Differential Fluid Change0.7 hr0.6 to 0.8
- Differential Fluid Change - Front0.8 hr0.7 to 0.9
- Differential Fluid Change - Rear0.7 hr0.6 to 0.8
- Differential Pinion Seal2.4 hr1.9 to 2.9
- Differential Rebuild - Front7.5 hr6.0 to 9.0
- Differential Rebuild - Rear10.0 hr8.5 to 11.5
- Driveshaft - Front1.6 hr1.4 to 1.8
- Driveshaft - Rear2.0 hr1.7 to 2.3
- Driveshaft Center Support Bearing1.8 hr1.4 to 2.2
- Front Differential7.5 hr6.4 to 8.6
- Limited Slip Clutch Pack5.4 hr4.3 to 6.5
- Locking Hub - Auto1.9 hr1.6 to 2.2
- Locking Hub - Manual1.5 hr1.3 to 1.7
- Rear Differential8.4 hr7.1 to 9.7
- Ring and Pinion6.6 hr5.3 to 7.9
- Transfer Case5.1 hr4.3 to 5.9
- Transfer Case Chain6.7 hr5.7 to 7.7
- Transfer Case Encoder Motor1.8 hr1.4 to 2.2
- Transfer Case Fluid Change0.8 hr0.6 to 1.0
- Transfer Case Motor/Actuator1.8 hr1.4 to 2.2
- U-Joint1.8 hr1.4 to 2.2
- Wheel Bearing - Press-In Front3.4 hr2.9 to 3.9
- Wheel Bearing - Press-In Rear3.8 hr3.2 to 4.4
- Wheel Bearing Hub - Front1.8 hr1.4 to 2.2
- Wheel Bearing Hub - Rear3.0 hr2.6 to 3.5
- Wheel Bearing Repack & Adjust - Front (Serviceable)2.5 hr2.1 to 2.9
- Wheel Stud - Front0.7 hr0.6 to 0.9
- Wheel Stud - Rear0.9 hr0.8 to 1.1
Transmission
- Automatic Transmission Fluid and Filter Change1.8 hr1.4 to 2.2
- Clutch Cable1.4 hr1.2 to 1.6
- Clutch Disc6.6 hr5.3 to 7.9
- Clutch Hydraulic Line1.8 hr1.4 to 2.2
- Clutch Kit7.8 hr6.2 to 9.4
- Clutch Master Cylinder1.7 hr1.4 to 2.0
- Clutch Slave Cylinder2.1 hr1.8 to 2.4
- Dual Mass Flywheel10.2 hr8.2 to 12.2
- Flywheel Resurface10.5 hr8.9 to 12.1
- Kickdown Cable1.2 hr1.0 to 1.4
- Manual Trans Fluid Change0.6 hr0.5 to 0.7
- Neutral Safety Switch1.0 hr0.9 to 1.2
- Overdrive Solenoid3.0 hr2.4 to 3.6
- Pilot Bearing7.8 hr6.2 to 9.4
- Pressure Plate6.6 hr5.3 to 7.9
- Shift Cable1.8 hr1.4 to 2.2
- Shift Fork10.2 hr8.2 to 12.2
- Shift Linkage1.8 hr1.4 to 2.2
- Shift Solenoid - Single3.6 hr3.1 to 4.1
- Shift Solenoids - All4.6 hr3.9 to 5.3
- Synchros - All15.7 hr13.3 to 18.1
- Synchros - Single Gear12.4 hr10.5 to 14.3
- Throw-Out Bearing7.8 hr6.2 to 9.4
- Torque Converter8.4 hr7.1 to 9.7
- Torque Converter Clutch Solenoid3.0 hr2.4 to 3.6
- Transmission Control Module1.1 hr0.9 to 1.3
- Transmission Cooler Lines1.8 hr1.4 to 2.2
- Transmission Filter1.5 hr1.3 to 1.7
- Transmission Filter and Fluid1.8 hr1.4 to 2.2
- Transmission Fluid Change0.8 hr0.6 to 1.0
- Transmission Flush1.2 hr1.0 to 1.4
- Transmission Input Shaft Bearing10.2 hr8.2 to 12.2
- Transmission Kickdown Cable Adjustment0.6 hr0.5 to 0.7
- Transmission Oil Cooler2.3 hr2.0 to 2.6
- Transmission Output Shaft Bearing7.8 hr6.2 to 9.4
- Transmission Pan Gasket1.8 hr1.4 to 2.2
- Transmission R&R - Automatic8.0 hr6.8 to 9.2
- Transmission R&R - Manual7.3 hr6.2 to 8.4
- Transmission Range Sensor1.2 hr1.0 to 1.4
- Transmission Rebuild - Automatic18.3 hr15.6 to 21.0
- Transmission Rebuild - Manual15.3 hr13.0 to 17.6
- Transmission Speed Sensor - Input1.0 hr0.9 to 1.2
- Transmission Speed Sensor - Output1.0 hr0.9 to 1.2
- Valve Body4.7 hr4.0 to 5.4
Exhaust
- Air Injection Check Valve0.9 hr0.8 to 1.0
- Catalytic Converter - Direct Fit1.8 hr1.4 to 2.2
- Catalytic Converter - Universal1.8 hr1.4 to 2.2
- Downpipe1.9 hr1.6 to 2.2
- EGR Cooler4.2 hr3.4 to 5.0
- EGR Tube1.4 hr1.1 to 1.7
- EGR Valve1.8 hr1.4 to 2.2
- Exhaust Clamp0.4 hr0.3 to 0.5
- Exhaust Gasket - Front2.9 hr2.5 to 3.3
- Exhaust Gasket - Rear3.0 hr2.4 to 3.6
- Exhaust Hangers0.6 hr0.5 to 0.7
- Exhaust Manifold Studs4.2 hr3.4 to 5.0
- Exhaust Pipe - Rear Section1.4 hr1.1 to 1.7
- Exhaust Tip0.4 hr0.3 to 0.5
- Flex Pipe1.8 hr1.4 to 2.2
- Front Pipe1.8 hr1.4 to 2.2
- Intermediate Pipe1.4 hr1.1 to 1.7
- Muffler1.0 hr0.8 to 1.2
- O2 Sensor - Downstream0.6 hr0.5 to 0.7
- O2 Sensor - Upstream0.6 hr0.5 to 0.7
- O2 Sensors - All1.7 hr1.4 to 2.0
- Resonator1.0 hr0.8 to 1.2
- Secondary Air Injection Pump1.4 hr1.2 to 1.6
- Tail Pipe1.0 hr0.8 to 1.2
Emissions
- Oxygen Sensor Replacement1.0 hr0.9 to 1.2
Heating and A/C
- AC Accumulator1.2 hr1.0 to 1.4
- AC Clutch Coil1.8 hr1.4 to 2.2
- AC Compressor2.4 hr1.9 to 2.9
- AC Compressor Clutch1.9 hr1.6 to 2.2
- AC Compressor Oil Add0.5 hr0.4 to 0.6
- AC Condenser1.8 hr1.4 to 2.2
- AC Evaporator6.0 hr4.8 to 7.2
- AC Expansion Valve (TXV)3.0 hr2.4 to 3.6
- AC High Pressure Switch0.6 hr0.5 to 0.7
- AC Hose - High Side1.4 hr1.2 to 1.6
- AC Hose - Low Side1.3 hr1.1 to 1.5
- AC Hose Assembly1.8 hr1.4 to 2.2
- AC Low Pressure Switch0.6 hr0.5 to 0.7
- AC Orifice Tube1.2 hr1.0 to 1.4
- AC Pressure Sensor0.6 hr0.5 to 0.7
- AC Receiver/Drier1.2 hr1.0 to 1.4
- AC Recharge0.6 hr0.5 to 0.7
- Blend Door Actuator1.4 hr1.2 to 1.6
- Cabin Air Filter0.4 hr0.3 to 0.5
- Climate Control Module0.9 hr0.8 to 1.0
- HVAC Control Panel0.9 hr0.8 to 1.0
- Mode Door Actuator1.6 hr1.4 to 1.8
- Recirculation Door Actuator1.8 hr1.4 to 2.2
Body
- Bed Rail Cap0.6 hr0.5 to 0.7
- Bedside Panel4.2 hr3.4 to 5.0
- Bumper Cover - Front1.3 hr1.1 to 1.5
- Bumper Cover - Rear1.0 hr0.9 to 1.2
- Bumper Reinforcement - Front1.9 hr1.6 to 2.2
- Bumper Reinforcement - Rear1.5 hr1.3 to 1.7
- Door Check/Stop0.5 hr0.4 to 0.6
- Door Glass1.4 hr1.2 to 1.6
- Door Handle - Exterior1.0 hr0.8 to 1.2
- Door Handle - Interior0.6 hr0.5 to 0.7
- Door Hinge1.8 hr1.4 to 2.2
- Door Shell3.5 hr2.8 to 4.2
- Door Skin4.2 hr3.4 to 5.0
- Door Weatherstrip0.9 hr0.8 to 1.0
- Fender1.7 hr1.4 to 2.0
- Fender Liner0.6 hr0.5 to 0.7
- Grille0.6 hr0.5 to 0.7
- Hood1.2 hr1.0 to 1.4
- Hood Hinge1.2 hr1.0 to 1.4
- Hood Latch0.6 hr0.5 to 0.7
- Hood Release Cable1.0 hr0.9 to 1.2
- Hood Strut0.4 hr0.3 to 0.5
- Liftgate3.3 hr2.8 to 3.8
- Liftgate Motor1.8 hr1.4 to 2.2
- Liftgate Strut0.6 hr0.5 to 0.7
- Quarter Glass1.0 hr0.9 to 1.2
- Quarter Panel7.0 hr6.0 to 8.1
- Rear Window1.8 hr1.4 to 2.2
- Rocker Panel5.3 hr4.5 to 6.1
- Side Mirror Glass0.3 hr0.2 to 0.4
- Tailgate0.8 hr0.7 to 0.9
- Tailgate Cable0.4 hr0.3 to 0.5
- Tailgate Handle0.6 hr0.5 to 0.7
- Tonneau Cover Install1.0 hr0.8 to 1.2
- Truck Bed Liner1.1 hr0.9 to 1.3
- Trunk Hinge1.2 hr1.0 to 1.4
- Trunk Latch0.8 hr0.6 to 1.0
- Trunk Lid1.1 hr0.9 to 1.3
- Trunk Strut0.5 hr0.4 to 0.6
- Vent Glass1.0 hr0.9 to 1.2
- Windshield1.8 hr1.4 to 2.2
- Windshield Molding0.7 hr0.6 to 0.8
Interior
- Armrest0.5 hr0.4 to 0.6
- Carpet3.1 hr2.6 to 3.6
- Center Console0.7 hr0.6 to 0.8
- Dash Pad3.1 hr2.6 to 3.6
- Dashboard6.8 hr5.8 to 7.8
- Door Panel0.6 hr0.5 to 0.7
- Floor Mat Hooks0.3 hr0.2 to 0.4
- Glove Box0.6 hr0.5 to 0.7
- Glove Box Latch0.3 hr0.2 to 0.4
- Headliner1.7 hr1.4 to 2.0
- Pedal Pads0.3 hr0.2 to 0.4
- Rearview Mirror0.4 hr0.3 to 0.5
- Seat - Front0.8 hr0.6 to 1.0
- Seat - Rear0.8 hr0.6 to 1.0
- Seat Belt0.6 hr0.5 to 0.7
- Seat Belt Buckle0.5 hr0.4 to 0.6
- Seat Belt Pretensioner0.8 hr0.7 to 0.9
- Seat Cover1.1 hr0.9 to 1.3
- Seat Foam1.5 hr1.2 to 1.8
- Seat Track1.2 hr1.0 to 1.4
- Shifter Boot0.6 hr0.5 to 0.7
- Shifter Knob0.2 hr
- Steering Wheel Cover0.3 hr0.2 to 0.4
- Sun Visor0.3 hr0.2 to 0.4
Other
- Engine Mount - Strut1.8 hr1.4 to 2.2
- Engine Mount - Torque Axis1.8 hr1.4 to 2.2
Hours are what a professional technician takes with the right tools. When a range is shown, it is the spread a job can take depending on condition. Parts are extra.
Need torque specs, fluids or repair steps for this car? See it on the Open Labor Project